1.6 Gti Wont Run Properly ( Cuts Out And Won't Rev )

[Gavin Waddell 18]

Hey guys need some help

 

I wanted to take my gti out for a spin this weekend, car started fine and after about 5 it started to play up was driving along and the revs seemed to just die then would come back and rev normally then would cut out again, Like it wasnt getting fuel properly. It was reply limp home mode as soon as I accelerated it would just not want to rev I could accelerate but nothing happened the it wouldn't just shoot up the revs. Im stumped.

 

It did the same about two weeks ago but only once or twice at the time the fuel relay wasn't attached properly and I thought it could be that as it was flapping about a bit,. Can than really affect a realy operating. I could hear the fuel pump whinnying so ruled out fuel delivery or not?

 

Then car has had new leads, dizzy cap rotor arm, temp sensor ( febi one) and emissions where set up for not

 

It rely p$$$ed me off.

 

Any Help or advice would be appreciated gavin

[toolie72 67 1 Cars]

Borrow a known good air flow meter?

[Gavin Waddell 18]

Would live to but i live in switzerland and they never got the boho version over here

[Gavin Waddell 18]

Sorry bloody predicated txt meant to say they never got the 115 Bhp version over her only 105 versions

[Telf 224 2 Cars]

The airflow meter is either a 1.6 or 1.9 version... borrow the reLavant one.

[PhilNW 44]

Check fuel pump and pressures

Edited November 1, 2016 by PhilNW

[Gavin Waddell 18]

Ok thanks guys, unthinking it my be the airflow as the car wasn't really stuttering as if the fuel pressure was dropping off but more hesitating as if it wasn't getting enough air.

 

For Checking fuel pressure what's the norm plug in pressure gauge or check fuel delivery with large bucket over a period of time. As so I get litres per minute?

 

Gavin

[Gavin Waddell 18]

Ok so took her out for a spin and nothing nonplayingnup what's so ever, it had trouble stating it would cut out so had a fiddle with the fuel relay and it started fine and ran with no hiccups. There like bloody women these cars will see how I get on

 

Thanks for your advice guys will probably do a check up over winter.

 

Gavin

[scottc2010 0 1 Cars]

I replaced the pipe from the oil filler cap to the sump - this helped a lot as mine had completely split - about 24 pounds from peugeot

[scottc2010 0 1 Cars]

also, if you are losing oil pressure it could be the oil pressure relief valve - about £3.50 again from Peugeot (don't use eBay as they rip you off saying they have a performance part for £8 which is actually just the same one from Peugeot)

You will need the valve (discharge piston) - part number 113313 and the piston spring - part number 115711

[PhilNW 44]

Ok thanks guys, unthinking it my be the airflow as the car wasn't really stuttering as if the fuel pressure was dropping off but more hesitating as if it wasn't getting enough air.

 

For Checking fuel pressure what's the norm plug in pressure gauge or check fuel delivery with large bucket over a period of time. As so I get litres per minute?

 

Gavin

Fuel pump should be able to deliver 45psi just after the pump but will deliver below that figure depending on revs

 

Tap into the pump with a proper fuel pressure guage (machinemart do one, lots on ebay)

 

Sounds exactly like what happened to mine, when tested was showing about 16psi