Gti-6 Not Starting

[jassi 1 1 Cars]

Hey Guys

 

Drove the car last night and was fine but refused to start this morning. Its cranking but wont start. Battery is ok and I can hear the fuel pump when key is turned to position 2. Did a quick google and GTI-6 forum suggests crank sensor which is on the GTI-6 gearbox but my conversion is using a 1.9 gearbox.

 

Thx

Edited September 7, 2016 by jassi

[Liam 0]

if you are on stock gti6 management it will be in the same place

[jassi 1 1 Cars]

I decided to investigate a bit further and found I was getting a spark and fuel. Checked the cambelt just in case and that was ok too. So with limited knowledge / skills I had it towed to a garage. They have investigated and suggesting that although there is fuel its not at a high enough pressure after initial cranking so still want to replace the fuel pump?

[welshpug 1,666]

the fuel pumps are very old now, they dont last forever.

 

got enough fuel in it?

[Anthony 1,003]

Hard to say without seeing the car and obviously the garage have so should be in a better position to comment/diagnose.

 

My gut feeling though is that the diagnosis doesn't quite sound right - I'm yet to see a fuel pump so bad that it still works but can't maintain enough flow/pressure to even start/idle. Sometimes the short hose that connects the actual pump to the fuel pump housing can perish and split, which if bad enough could behave as the garage are saying - I'd be surprised if it had been working 100% the previous day though.